The Dispatch | Expert | Scudo Hub

Get help & share your Citroen Dispatch (Jumpy) | Peugeot Expert | Fiat Scudo tips

You are not logged in.

#1 2017-12-24 10:57:09

Andyjcb1
Member
Registered: 2017-12-24
Posts: 6

Can anyone help? Missing part of my 03 dispatch

Hi, I have a air intake pipe missing on my 03 diesel dispatch everything is there from the filter box to the engine side but from the filter box there is nothing but the large hole on the intake side, does anyone know the part I need or could sell me the part, thanks Andy my postcode is dy53ry Dudley area

Offline

#2 2017-12-24 11:35:16

Andyjcb1
Member
Registered: 2017-12-24
Posts: 6

Re: Can anyone help? Missing part of my 03 dispatch

IMG_20171224_102252496.jpeg

Offline

#3 2017-12-24 14:30:21

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,002

Re: Can anyone help? Missing part of my 03 dispatch

If that just goes to a gap it the front of the van to collect fresh air then i dare say almost any rubber/plastic flexible pipe will do. Just get a bit slightly thinner that the bit you see so your new one fits inside and tape over the gap. Other end to hole/gap at the front.

Offline

#4 2017-12-24 15:03:37

Andyjcb1
Member
Registered: 2017-12-24
Posts: 6

Re: Can anyone help? Missing part of my 03 dispatch

Thanks, it does go to the front cross member I think, its quite barky and got a diesel knock when first started for a few minutes, there is not a sensor in-between is there? Hope not lol
Thanks Andy

Offline

#5 2017-12-24 15:32:57

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,002

Re: Can anyone help? Missing part of my 03 dispatch

Andyjcb1 wrote:

Thanks, it does go to the front cross member I think, its quite barky and got a diesel knock when first started for a few minutes, there is not a sensor in-between is there? Hope not lol
Thanks Andy

Not got my Pug anymore to check but i dont remember a sensor. If it did you would have a connector dangling around that area.

Offline

#6 2017-12-24 16:55:17

Andyjcb1
Member
Registered: 2017-12-24
Posts: 6

Re: Can anyone help? Missing part of my 03 dispatch

Thanks, keep rocking lol I sang with Duncan Scott (drummer) diamond head in the early 90s, am I evil lol only claim to fame oh well

Offline

#7 2017-12-24 23:10:25

vaz2121
Member
From: SW. Scotland
Registered: 2015-08-31
Posts: 317

Re: Can anyone help? Missing part of my 03 dispatch

On my van it's just a concertina d pipe that tucked/runs behind N/S Headlight to a orifice on the inner wing to collect cooler air I suspect....
So as Casper says some ducting will do the trick ...... There's No Air Flow Sensor on a 1.9 DW8

Measure the bore on the air filter box pop down breakers see what they've got.... not that your very likely to find one now but escort vans had a long intake pipe

Online

#8 2017-12-25 09:39:55

Andyjcb1
Member
Registered: 2017-12-24
Posts: 6

Re: Can anyone help? Missing part of my 03 dispatch

Thanks guys and merry Christmas all

Offline

Board footer