The Dispatch | Expert | Scudo Hub

Oscarklemo

Member

From: Sweden

Registered: 2025-04-30

Posts: 57

washer jumpy

Hello!

My next project was to fix the washer for my jumpy.

The original issue was that when I was refilling it, my feet got wet..

Removed the front bumper and noticed a hole in the reservoir. I can see I am obviously missing a part. Found a gasket for my houses floor heating system which fitted perfectly. Its the white part. But then I tried filling it up and trying it and nothing happened. The right part would be the pump if I'm correct. I tried another pump and then it works, so its probably the pump. Ill try to find a new one.

I have two cable coming down. One with a Green connector, reaching to the Green connector on the pump, and one with a black connector, reaching to the missing part so probably it's supposed to go there

Now to my real question. Does anyone know what the circled part is and do I need it? Edit: could it be the "low level" sensor?

Last edited by Oscarklemo (2025-06-22 22:14:29)

---

1998 Citroen Jumpy 1.9TD XUD9 TE

RegW

Member

From: Bristol

Registered: 2024-04-21

Posts: 334

Re: washer jumpy

I'm just guessing, but I reckon the large one circled in red is the screen wash pump and the smaller one
is for a vehicle with a headlamp washer or its a supply to a rear screen wash.

---

When all else fails, RTFM  - 2006 Expert 2.0 HDI/110

Oscarklemo

Member

From: Sweden

Registered: 2025-04-30

Posts: 57

Re: washer jumpy

I have no rear washer.

I do have headlight washers.

But googling jumpy windscreen washer makes the one with the green connector come up.

Checking eper  at the fiat forum, I can't really tell if there is one or two pumps. It's only one switch in the car for both washers as I think it's the same pump.

I found an identical pump (with the green connector) at a Swedish aftermarket car parts store fitting a 90s Volvo. I think I'll try it out. Right now my front is still off, so its need to fix it to be able to drive the car. (Too lazy to put it back and then off again)

---

1998 Citroen Jumpy 1.9TD XUD9 TE

Gregor887

Member

From: Poland

Registered: 2024-11-25

Posts: 14

Re: washer jumpy

In the 90s I had Ford Transit - version for Finland. It had two washer pump also. Bigger for the front lamp, both worked at one time. I disconnected for a few months this one on the lamps. Thick tube, efficient pump, every time working with the sprinkler front glass.
Buy the reservoir with one pump and forget about the problem.

---

2005 Jumpy 2,0HDI/110

Oscarklemo

Member

From: Sweden

Registered: 2025-04-30

Posts: 57

Re: washer jumpy

In the 90s I had Ford Transit - version for Finland. It had two washer pump also. Bigger for the front lamp, both worked at one time. I disconnected for a few months this one on the lamps. Thick tube, efficient pump, every time working with the sprinkler front glass.
Buy the reservoir with one pump and forget about the problem.

I bought the Volvo pump today. Will try to fit it tomorrow but it looks identical to the eye. It was €18. It it fits, I don't need to buy a new reservoir. I'll report back.

---

1998 Citroen Jumpy 1.9TD XUD9 TE