The Dispatch | Expert | Scudo Hub

Get help & share your Citroen Dispatch (Jumpy) | Peugeot Expert | Fiat Scudo tips

You are not logged in.

#1 2019-01-25 17:10:53

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Dispatch 1.9TD for spares (24k engine, subframe) or repair

2000 Dispatch 1.9TD dark blue - took it in for an early pre-MOT check today, as I really needed to be sure it would get through next month due to an impending house move from Scotland down to Manchester, although the MOT doesn’t actually expire until 12 March.  Sadly it’s not going to pass without considerable welding and this is probably going to be the end of the road.  The welding and an exhaust rubber are the only things that would have been required for a new MOT at the moment.

It’s had a lot spent to get it this far and I’m wondering if anyone is interested in buying it in particular for the engine and/or front subframe.  The van has covered around 94k and runs perfectly, but the engine was replaced with a Citroen exchange unit at around 70k, so this one has done only 24k since then.  The turbo was replaced at the same time, having been responsible for the original engine failure. 

The front subframe was replaced around 6 or 7 years ago with a brand new one which I think was one of the last available from Citroen, so there should be plenty of life left in that if anybody needs a good used one.

I still need the van for a couple of trips between Helensburgh and Manchester over the coming month, so not looking to let it go immediately, but if anyone would like to see it or discuss it please get in touch.  I’ve known the van since it was new as it was originally purchased by a friend (now deceased)

I’m not in a position to break the van myself, so would only sell it as a complete vehicle.

Offline

#2 2019-01-25 18:52:22

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Where is the welding needed? Large or small patched and i presume close to something structural

Offline

#3 2019-01-25 20:32:17

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Both front jacking points.  Rear of nearside sill.  Extremities of both corners inboard of the rear bumper  sad  sad

Offline

#4 2019-01-25 21:11:07

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Sill i would do. Extremities of both corners inboard of the rear bumper? < Is that all the rear corner what the bumper his hiding and attached to? Probably do that myself also But Jacking points has me spooked. Is there extra support rotted away/needed.

Im after a cheap van for work and this would have been ideal. Unfortunately your two locations is a tad far for just a casual viewing.

Offline

#5 2019-01-25 21:42:02

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

If you get a chance mail me some pictures of the damage and the reg number if you dont want to type it here. rolfe66@gmail.com

Offline

#6 2019-01-26 09:01:19

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

I’ll email details and pictures later this morning.
I’m told that the jacking points are relatively straightforward to fix and probably the easiest of the affected areas to deal with.

Offline

#7 2019-01-26 12:11:06

kenbw2
Member
From: Bradford/Preston/Anywhere
Registered: 2017-11-26
Posts: 236

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Wouldn't mind some pictures posted on here. I'm mostly around Bradford but sometimes drive to Preston.

A 24k XUD9 with similarly aged turbo seems tempting. Depends if I can be arsed moving all my camper conversion across!


1999 Citroen Dispatch 1.9D DW8 Camper Conversion
1996 Peugeot 806 1.9TD XUD9 Spare vehicle
1998 Citroen Synergie 1.9TD XUD9 Snapped timing belt

Offline

#8 2019-01-26 13:40:11

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Happy to post pictures but after uploading them I’m unsure how to proceed as the insert function doesn’t seem to do anything.  Alternatively I can email them.  The corrosion is fairly daunting though!  I’ll be in Manchester with the van from tomorrow until Wednesday morning.

Offline

#9 2019-01-26 13:46:44

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

I will upload the ones you sent me if you want. You bothered about the numberplate showing?

Offline

#10 2019-01-26 13:55:01

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Thanks, that’s fine, please go ahead

Offline

#11 2019-01-26 14:00:19

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

06.jpg
07.jpg
08.jpg
05.jpg

And the bad bits

04.jpg
03.jpg
02.jpg
01.jpg

Offline

#12 2019-01-27 02:15:50

kenbw2
Member
From: Bradford/Preston/Anywhere
Registered: 2017-11-26
Posts: 236

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

18 mentions of "corroded" in its MOT history! Has it been washed with salt water or something?

Screenshot-from-2019-01-27-01-12-19.png

I'd be up for a look though. I'm down in Somerset atm, will be driving up to Bradford on Sunday so would be coming past Manchester. Where abouts are you?

Depending on how I get on with times I could swing by. Would be later on though - 8 - 10pm onwards if that's not too late - my DW8 can only go so fast!

Last edited by kenbw2 (2019-01-27 02:21:07)


1999 Citroen Dispatch 1.9D DW8 Camper Conversion
1996 Peugeot 806 1.9TD XUD9 Spare vehicle
1998 Citroen Synergie 1.9TD XUD9 Snapped timing belt

Offline

#13 2019-01-27 05:11:28

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Lol! I haven’t counted but a bit of duplication surely to get to 18?!  This evening should be fine, probably best if you email me and I’ll get back to you or give you a call this afternoon once I arrive.  dispatch@skipport.co.uk

Offline

#14 2019-01-27 17:31:16

kenbw2
Member
From: Bradford/Preston/Anywhere
Registered: 2017-11-26
Posts: 236

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Yea there's a few where it was an advisory one year and a fail the next.

I'm on my way back up North, I'll drop you an email

Anything you specifically want me to check for you Casper?


1999 Citroen Dispatch 1.9D DW8 Camper Conversion
1996 Peugeot 806 1.9TD XUD9 Spare vehicle
1998 Citroen Synergie 1.9TD XUD9 Snapped timing belt

Offline

#15 2019-01-27 21:14:39

Casper
Member
From: East Lothian
Registered: 2015-12-20
Posts: 1,207

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

kenbw2 wrote:

Anything you specifically want me to check for you Casper?

No thank you Kenbw2. The welding is beyond me as i only just started to teach myself. A welder should be part of the LDV Convoy tool kit big_smile

Offline

#16 2019-01-30 13:31:49

vaz2121
Member
From: SW. Scotland
Registered: 2015-08-31
Posts: 465

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Living on the Coast at Helensburgh maybe does't help matters............. Looks like whats been thrown up by the Clyde and youve driven through as the outer sill skins look fresh.... Ive just had mine (sills) dealt with again because of mostly standing idle over best part of last year and I obviously never delt with blistering issue entirely the first time..............

Seems mine is exact oposite undeneath is actually very good............. The underseal coat looks breached and thats got to be salty air dampness got in there or as I said maybe salty puddles...... Still it's nearly 20 yrs old and looks to be able to provide a good few decent low mileage parts

Offline

#17 2019-02-01 17:38:10

dauphin
Member
From: Helensburgh
Registered: 2017-03-03
Posts: 10

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

I’ve tried to keep it off the salty winter roads and garaged as far as possible since it came to Helensburgh but I think its Hebridean origins have taken their toll.  Hopefully someone can make good use of the parts; had a great run down to Manchester and back earlier this week

Offline

#18 2019-02-04 13:26:31

vaz2121
Member
From: SW. Scotland
Registered: 2015-08-31
Posts: 465

Re: Dispatch 1.9TD for spares (24k engine, subframe) or repair

Spending many a year on the islands on and off ferries or just the fact of being on the islands rough weather and salty moist air is never far away............ In the early/mid 80's as a nipper I lived just outside Turnberry right on the clyde coast. (Area famous for Ayrshire potatoes) I had A MK2 Ford Escort and by the time it was 6 years old it was rotten like a Pear ....... A friend had a similar problem with his Fiesta barely past it MOT when 4yrs old and scrapped at 5yrs through rot..... He had bought it new in 1988..... So vans done not bad living in that kind of enviroment......................

Offline

Board footer