The Dispatch | Expert | Scudo Hub

Get help & share your Citroen Dispatch (Jumpy) | Peugeot Expert | Fiat Scudo tips

You are not logged in.

#1 2019-02-23 07:23:33

Kempy99
Member
Registered: 2019-02-23
Posts: 3

2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

Hi everyone. I'm new to this site so please be gentle with me!!
I have a rotten 2002 scudo 2.0 jtd with a good engine and a good 1.9d with a rotten engine! Can I swap the good 2L into the good 1.9d chassis? Any help greatly appreciated ???

Last edited by Kempy99 (2019-02-23 07:25:59)

Offline

#2 2019-02-23 07:35:16

Kempy99
Member
Registered: 2019-02-23
Posts: 3

Re: 2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

Or are the gearboxes the same so I can use the good clutch? Cheers

Offline

#3 2019-02-23 07:57:24

Alvin
Member
Registered: 2019-02-19
Posts: 6

Re: 2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

Only just got a van myself, but from my knowledge of 306s using the same engines it will physically fit no problem, I would guess the gearboxes are interchangable but would need the fork mechanism swapping. On the 306s one was a push type clutch and one was a pull type. As for the engine, wiring would be the headache there is a whole lot more of it required for the 2.0.

I think its possible but long winded. Someone with more experience should be able to give a more concrete answer though.

Offline

#4 2019-02-23 16:52:21

vaz2121
Member
From: SW. Scotland
Registered: 2015-08-31
Posts: 481

Re: 2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

Alvin wrote:

Only just got a van myself, but from my knowledge of 306s using the same engines it will physically fit no problem, I would guess the gearboxes are interchangable but would need the fork mechanism swapping. On the 306s one was a push type clutch and one was a pull type. As for the engine, wiring would be the headache there is a whole lot more of it required for the 2.0.

I think its possible but long winded. Someone with more experience should be able to give a more concrete answer though.

I'm going to say what (Alvin) he said.......... Use both engine and box from HDI as I think the gearing might be slightly better having more power than 1.9D plus there may be a few pick ups on it that you'll need..... you'll most likely have to use fuel tank unless lift pump is intechangable or exterior........... and yes Alvin is correct the engine and g/box going in is the easy bit ..... you'll need engine loom .... ECU and probably a  mountain of other bit off HDI ....but at least you have both vans to compare whats what and have/get a good workshop manual......... It will be do-able ............ (Number of years ago I put a 2ltr in a Nova (Corsa).... But I only needed 3 wires to make it run and NO Fly-By Wire  and a lot of mix N match)

Offline

#5 2019-02-23 20:06:36

Kempy99
Member
Registered: 2019-02-23
Posts: 3

Re: 2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

Thanks everyone, just need a quiet spell to get it done or wait for the clutch in the 1.9 to go and be forced into it!! ?

Offline

#6 2019-02-23 23:15:41

kenbw2
Member
From: Bradford/Preston/Anywhere
Registered: 2017-11-26
Posts: 249

Re: 2000 scudo 2.0 jtd engine and gearbox into a 2002 scudo 1.9 d

This guy put the earlier 1.9 XUD9 into a Synergie (same thing, lower roof) that came with the 2.0 HDi. He had to bodge a new engine mount but that looked like it.

https://www.youtube.com/watch?v=dnIbYwfV8xk


2000 Citroen Dispatch 1.9TD XUD9 Upcoming Camper
1999 Citroen Dispatch 1.9D DW8 Camper Conversion + full time home
1996 Peugeot 806 1.9TD XUD9 Spare vehicle
1998 Citroen Synergie 1.9TD XUD9 Snapped timing belt

Offline

Board footer